FAQs Archive

Q: My store uses Huebsch dryers, model JT0300DFG. I am having an issue. Sometimes when I put coins into the machine, it doesn't work and the symbol "ERR" displays and blinks. Other times that symbol is gone and returns to normal status.

The coin drop is dirty. Remove, take apart and remove all the lint. If the issue continues replace the drop.

Q: We have a model #JT0350SEL-ser#R0009000117. It shuts off one second after starting. We have cleaned the entire machine but it appears the air flow switch is tripping out. Any suggestions?

If the air flow switch is opening as stated then there is a major restriction in the exhaust system, the fan is not operating, there is a plugged lint filter or there is a major air leak between the cylinder and lint compartment.

Q: I have Huebsch dryers and the back of the drums are all turning brown. It looks like it is scorched from the use of fabric softeners. What is the best way to clean it?

Some 409 cleaner and a Brillo pad will remove the excess softener build up.

Q: We have MDC top load DOE washing machines in our laundry rooms. There are either three or four machines in each laundry room. We are looking to replace the existing hot water tanks with tankless hot water units. The suppliers are not certain of the size of tankless unit to supply either the three or four machine scenario. Can you advise me on the correct tankless sized unit?

The estimated hot water usage is 16 gallons per cycle per washer and the cycle time is 34 minutes. You will need to use this info to calculate heater size.

Q: I am in the process of buying a coin laundry and I would like to know how much water a Huebsch 27 lb, model HC27 uses, as well as a 35 lb, model JTO300drg.

1) Water consumption is dependent on the programmed number of baths and the programmed water levels. The Huebsch HC27 washer you mention is at least 10 years old and probably has a mechanical timer. Water consumption for a regular cycle is approximately 62 gallons of water per cycle – 10 gallons of hot water and 52 gallons of cold water. The comparable 35-pound capacity washer uses 102 gallons of water per cycle. Huebsch washers have gone through a lot of changes in the last 10 years. All models now use the new Galaxy Control which offers tremendous flexibility for the owner. This includes the ability to control water levels and to charge a higher vend depending on the number of baths requested. By default, a Huebsch Galaxy 600 – 30 lb capacity washer-extractor uses just 26 gallons of water. Now would be a good time to consider replacing those 10+ year old machines. Current Huebsch washer-extractors ship with water usage of approximately 0.8 gallons per rated pound capacity using a three bath cycle. Approximate electrical power usage per load = 0.13 kWH per load for the SC27 and 0.21 kWh per load for the SC35. 2) If you have not done so, get the current sewer and energy bills for the laundromat to verify actual consumption. 3) A drying tumbler model (JT0300) was referenced at the bottom. Dryer gas consumption is highly dependent on the washer G-Force, the amount of make-up air provided and the venting. JT0300s are very efficient compared to other dryers built at that time. If you assure the drying tumblers have sufficient make-up air, have been maintained and cleaned of lint, and that the exhaust system is clean and correctly installed you will have completed the most important steps to obtain fast drying and lower energy cost.

Q: Is there a specific type of PDA required to use the Galaxy control on Huebsch machines?

The PDA has to run Microsoft Windows Mobile 2003 or greater in order to work with the Galaxy software. Your Huebsch distributor can provide you a list of tested PDA models.

Q: What is the cost of electricity for drying a 30 lb wash load?

This is a good estimate, but your results will vary: Assumptions: 30 lb dry weight load of cotton towels, 100G washer-extractor, dried in 45 lb natural gas tumbler Electricity cost = $0.12/kWH, natural gas cost = $1.00/therm Huebsch Dryer Energy cost for the 30 lb load: Total energy cost to dry = $0.52* *$0.46 for natural gas and $0.06 for electricity If you dry with an electric heated tumble dryer as the question states, it is much more expensive, typically two to three times the total energy cost of a natural gas heated drying tumbler. For this financial reason, almost no vended laundries use electric heat drying tumblers.

Q: I have a 20 lb washer, model #HC20BC20V6001. I would like to know how I can change the amount charged, and is there any sequence used in order to give a free wash with out having to open the machine. We are using control system 0231589-1*.

Since you have a B-Control machine, the machine has to be programmed manually and the machine has to be opened briefly to get into manual programming mode. Once you are in programming mode it is very easy to change the vend price.

Q: I recently bought a Huebsch washer and I'm very satisfied by its performance. However, I was wondering if I can rinse the laundry with warm water instead of only with cold water? Model number: ZWN311SP111CW01 Serial number: 1107008829 Load size: 16 pounds

The washer was designed to meet the Canadian Office on Energy Efficiency requirements and to do so it can not offer a warm rinse.

Q: We have a new #HWTT20WN washing machine in a commercial building. The plumbing code requires external backflow preventers on the water piping, unless the washer has an internal air gap conforming to ASSE 1007. Does this washing machine have an internal air gap conforming to ASSE 1007?

Yes, our UL Safety Certification for Clothes Washers requires testing and reviews to the standard UL2157, which includes a section on plumbing. This cites that the washer does comply with ASSE 1007.